Chevrolet Cruze manuals

Chevrolet Cruze Repair Manual: Front Side Door Window Adjustment

Warning: Refer to Glass and Sheet Metal Handling Warning in the Preface

Warning: Refer to Glass and Sheet Metal Handling Warning in the Preface section.

Warning: Refer to Express Window Down Warning in the Preface section.

Preliminary Procedure

  1. Remove the front side door trim. Refer to Front Side Door Trim Replacement.
  2. Remove the water deflector. Refer to Front Side Door Water Deflector Replacement.
  1. Front Side Door Window Regulator Sash Nut (Qty: 2)

Caution: Refer to Fastener Caution in the Preface section.

Tighten 10 N·m (89 lb in)

  1. Front Side Door Window

Procedure

  1. Loosen the window regulator sash nuts.
  2. Connect the door trim panel wire connector.

Note: Start the vehicle to ensure maximum power to the window motor. This is required in order to fully seat the window for adjustment.

  1. Start the vehicle.
  2. Using the power window switch, raise the window to the full up position.
  3. Tighten the front side door window regulator sash nuts.
  4. Inspect for proper window operation and a tight seal.
  5. Shut off the vehicle.
Installation Procedure
Remove all mounds or loose pieces of urethane adhesive from the pinch-weld area. Inspect for any of the following problems in order to help prevent future breakage of the window: High ...

Front Side Door Window Replacement
Preliminary Procedure Position the window approximately half   way down in the door. Remove the water deflector. Refer to Front Side Door Water Deflector Replacement. Remove t ...

Other materials:

Rear Bumper Fascia Guide Replacement
Preliminary Procedure Remove the rear bumper fascia. Refer to Rear Bumper Fascia Replacement. Rear Bumper Fascia Guide Rivet (Qty: 4) Special Tools BO-594-A Hand Rivet Tongs For equivalent regional tools, refer to Special Tools. Rear Bumper Fascia Guide Rear Bumper Fascia Inner ...

New Vehicle Break-In
Notice: The vehicle does not need an elaborate break-in. But it will perform better in the long run if you follow these guidelines: • Do not drive at any one constant speed, fast or slow, for the first 805 km (500 mi). Do not make full-throttle starts. Avoid downshifting to brake or slow the v ...

Customer Satisfaction Procedure
Your satisfaction and goodwill are important to your dealer and to Chevrolet. Normally, any concerns with the sales transaction or the operation of the vehicle will be resolved by your dealer's sales or service departments. Sometimes, however, despite the best intentions of all concerned, ...

© 2011-2024 Copyright www.ccruze.com