Chevrolet Cruze Repair Manual: Windshield Washer Nozzle Hose Replacement
Preliminary Procedure
- Remove the hood insulator. Refer to Hood Insulator Replacement.
- Place a clean container under the front driver side near where the windshield washer nozzle and windshield washer pump hose will be disconnected.
- Recover all lost windshield washer solvent.
- Windshield Washer Nozzle Hose
Tip
Disconnect the washer hose from both hood mounted washer nozzles.
- Windshield Washer Hose Retainer to Hood Hinge
- Windshield Washer Nozzle Hose Integral Connector
Tip
Disconnect the hoses in order to remove the windshield washer nozzle hose.
- Windshield Washer Pump Hose
Windshield Washer Nozzle Replacement
Preliminary Procedure
- Disconnect the washer hose from the washer nozzles.
- Remove the hood insulator. Refer to Hood Insulator Replacement
Windshield Washer Nozzle Assembly
Tip
Pinch the washer nozzle from the bottom side in order to release the nozzle and push the nozzle outboard from the hood to remove.
Windshield Washer Solvent Container Filler Tube Replacement
Windshield Washer Solvent Container Filler Tube Assembly
Procedure
- Pull the upper tube assembly from the lower washer container and inspect
the grommet (1), replace if damaged.
Refer to Windshield Washer Solvent Container Grommet Replacement.
- Insert the tube rib flush to the top seal at the lower container.
Windshield Washer Solvent Container Grommet Replacement
Preliminary Procedure
Remove the windshield washer solvent container filler tube assembly. Refer to Windshield Washer Solvent Container Filler Tube Replacement
- Windshield Washer Solvent Container Grommet
Wipers and Washers
Specifications
Wiper/Washer Schematics
Windshield Wiper and Washer Switch Replacement
Preliminary Procedure
Remove the steering column trim covers. Refer to Steering Column Low ...
Windshield Washer Pump Replacement
Removal Procedure
Remove the front wheelhouse liner. Refer to Front Wheelhouse Liner
Replacement.
Disconnect the washer pump electrical connector (1).
Disconnect the washer pump hose (2 ...
Other materials:
StabiliTrak® OFF Light
This light comes on briefly while starting the engine. If it does not, have the
vehicle serviced by your dealer.
This light comes on when the StabiliTrak system is turned off.
If StabiliTrak is off, the Traction Control System (TCS) is also off.
If the TCS is off, the system does not assist i ...
SIR Inflator Module Handling and Storage Warning
Warning: When carrying an undeployed inflator module:
Do not carry the inflator module by the wires or connector.
Make sure the air bag opening points away from you.
When storing an undeployed inflator module:
Make sure the air bag opening points away from the surface on which
the in ...
All-Season Tires
This vehicle may come with all-season tires. These tires are designed to provide
good overall performance on most road surfaces and weather conditions. Original
equipment tires designed to GM's specific tire performance criteria have a TPC specification
code molded onto the sidewall. Origi ...
